Open-cell and closed-cell polyurethane foam that air-seals and insulates in one application — installed on roof decks, walls, and crawl spaces throughout Clay County.
The reason spray foam keeps coming up in Clay County is humidity, not temperature. Clay County homes lose comfort to moisture as much as to heat, and a vented attic pulls damp outside air across everything in it — including the ductwork. Closed-cell foam applied to the underside of the roof deck brings that whole volume inside the building envelope, so the ducts are no longer running through a hot, wet space. Homeowners describe the result as the air feeling drier, which is exactly what has happened.
In Clay County, spray foam earns its cost in two places: the roof deck and the crawl space or block wall. Applied to the deck, closed-cell foam turns a vented attic into a conditioned one and adds measurable racking and uplift resistance to the sheathing — not a small consideration in a part of Florida that plans its year around hurricane season. Applied to walls, it fills the irregular cavities that batts never quite fit, which is common in older Clay County construction.
Clay County sits in Florida Climate Zone 2 — hot and humid, with a longer cooling season than almost anywhere else in the country. Under the Florida Building Code, Energy Conservation (8th Edition), the ceiling minimum here is R-38 and framed walls are R-13. ENERGY STAR recommends R-49 for an uninsulated attic in this zone; we build to R-38 to R-49 as the practical target.
| Item | Value | Where it applies |
|---|---|---|
| Open-cell foam | R-3.7 per inch | Roof decks, interior walls, sound control |
| Closed-cell foam | R-6.5 to R-7.0 per inch | Roof decks, crawl spaces, block walls, flood-prone areas |
| Air sealing | Effectively eliminates envelope air leakage at the application surface | Both types |
| Vapor behavior | Closed-cell is a Class II vapor retarder at 1.5" and above | Closed-cell only |
We inspect the attic, roof deck condition, duct location, and any existing insulation, and confirm the roof has enough service life left to justify foam.
Existing insulation is removed where required, penetrations are prepped, and the work area and HVAC returns are masked and protected.
Foam is sprayed in controlled lifts to the specified thickness, checked with a depth gauge as we go rather than by eye.
The space is ventilated per the manufacturer's re-occupancy schedule before anyone goes back in.
We measure thickness, photograph the finished surface, and hand over documentation for permits, insurance, or a future sale.
Spray foam in Clay County typically runs $3.00 to $7.00 per square foot depending on foam type and thickness. A full closed-cell roof deck encapsulation on a 2,000 sq ft Clay County home usually lands between $6,000 and $13,000; open-cell on the same deck is meaningfully less.
Not sure spray foam is the right call? These are the other scopes we run in Clay County — and the Clay County insulation overview covers the whole envelope.
Loose-fill fiberglass or cellulose blown to a consistent, verified depth across Clay County attic floors — the fastest way to bring an under-insulated attic up to code.
Blown-In Insulation in Clay County →Pre-cut fiberglass and mineral wool batts fitted between studs, joists and trusses in Clay County homes, additions, garages and light commercial framing.
Batt Insulation in Clay County →HEPA-filtered vacuum removal and disposal of wet, contaminated, storm-damaged or rodent-infested insulation from Clay County attics, walls and crawl spaces.
Insulation Removal in Clay County →Attic, wall, floor and air-sealing work for Clay County houses, condos and townhomes — the whole envelope handled by one contractor instead of four.
Residential Insulation in Clay County →Envelope, mechanical and fire-rated insulation for Clay County offices, retail, restaurants, hotels, medical buildings, warehouses and cold storage — including night and weekend work in occupied space.
Commercial Insulation in Clay County →Spray foam in Clay County typically runs $3.00 to $7.00 per square foot depending on foam type and thickness. A full closed-cell roof deck encapsulation on a 2,000 sq ft Clay County home usually lands between $6,000 and $13,000; open-cell on the same deck is meaningfully less. Standard Insulation gives free written itemized estimates throughout Clay County and Clay County — call (561) 975-6204.
Clay County sits in Florida Climate Zone 2 — hot and humid, with a longer cooling season than almost anywhere else in the country. The Florida Building Code, Energy Conservation (8th Edition) sets a R-38 minimum for ceilings in this zone, and R-38 to R-49 is the practical target for comfort and utility savings. Many Clay County homes built before 2005 still measure R-11 to R-19, which is a large part of why their summer bills run high.
Yes. Standard Insulation is a licensed Florida insulation contractor carrying general liability and workers' compensation coverage, and we work throughout Clay County and all of Clay County. Certificates of insurance are provided to homeowners, general contractors and property managers on request before any work begins.
We answer the phone 24 hours a day, 7 days a week. In Clay County we can usually be on site for a free assessment within 24 to 48 hours, and emergency insulation removal after a roof leak or storm gets same-day priority whenever we can make it happen.
Most Clay County residential jobs are completed in a single day. Larger homes, full removals and commercial scopes in Clay County run two to four days. We give you a firm window before we start and we call if anything changes.
Cooling is roughly half of a typical Clay County electric bill. Bringing an under-insulated attic up to a properly air-sealed R-38 to R-49 commonly cuts the cooling portion by 20 to 30 percent — more if your ductwork runs through the attic. On a $300 summer bill that is usually $30 to $45 a month back.
It depends on the building and the budget, and we will tell you honestly which applies. If your attic is at R-13 and you want the most improvement per dollar, blown-in to R-38 to R-49 with proper air sealing is the answer. If your ducts are in the attic and you want humidity control, closed-cell spray foam on the roof deck is the answer. If your roof is more than twelve years old, do the roof first — we will say so.
These are the outside sources we work from. None of them are ours — check them yourself before you sign anything with any contractor.
Written, itemized, and no obligation. We answer the phone 24 hours a day.
Request your free estimate 📞 (561) 975-6204
More about Spray Foam Insulation statewide · All Clay County locations · Insulation blog
